iATN Member Chrysler Auto Repair Tech Exchange for April 10, 2008

Overview | » TechHelp | Web Forums | Technical Resources | Live Conferencing | How to Join

Prev	iATN Members TechHelp for April 10, 2008 Automotive Technical Exchange for the Automotive Repair Professional	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for Chrysler

	Help Request	Answers
	1999 Chrysler Concorde 3.2L evaporator Hey All., Sorry about this super technical post. Were is the third through bolt for the evap case? Aldata says there are three and I can only find two. I've spent and hour looking for this thing and I fiqure someone here can bail me out. I believe I have all t...	View
	2003 Chrysler PT Cruiser 2.4L Fan Circuit Used car with inop ac. Evac and recharge system. No leaks verified. Bleed off valve started releasing r-134 while finishing recharge of system. Verified fan stopped spinning and was not coming on with a/c. Only opperating with engine temp. My beleif was either...	View
	2004 Chrysler Pacifica 3.5L Auto Stick This vehicle came in with the autostick staying in low gear when car is cold. In the morning when you get in and place trans in drive the prndl display shows all autostick digits lit up and the car will not shift out of low. After a little while trans works fi...	View
	2005 Chrysler Town & Country 3.8L cv joints inner hi, thanks for your time. One of my clients has had 2 axle shafts break in the last 1,000 miles, both times this has occured when making a hard turn (park lot) I can find no damage and the cradle looks to be in the proper place, I saw the tsb regarding the pow...	View
	1997 Dodge Stratus 2.5L Poor Idle Quality, Hesitation, Misfire, MIL Lamp on Engine runs rough at idle and hesitates on acceleration. I tried to motorvac the vehicle but no help. Fuel pressure is good. Volume is good. Checked for vacuum leaks with smoke machine. No leaks found. I'm thinking I have partially plugged injectors. I don't r... Trouble codes: P0300 (Randommultiple misfire detected.), P0171 (System too lean bank 1).	View
	2001 Dodge Caravan 3.3L MIL Lamp on Have a stubborn evap code here and I seem to be overlooking something. Have reveiwed posts and checked vacum lines by airbox area and have replaced LDP and bad gas cap due to locking part of cap not working. Still have a 456? Have smoke tested the sytem for le... Trouble codes: P0456 (evap system small leak detected).	View
	2002 Dodge Pickup 4.7L Surge, Cuts out, Stall this dodge idles great in park and in gear. let the rear wheels turn it dies. rear wheels off the ground, truck idling in nutural spin rear tires by hand the truck dies. i can give it some gas and drop it in gear on jack stands and it will run but it runs very... Trouble codes: p0601 (pcm internal self test fail).	View
	2003 Dodge Grand Caravan 3.3L abs sensor Hi, Guys I have this van that come in with a ABS light on and code for right rear speed sensor signal malfunction. Test drove and found that the right rear speed signal on the scanner is 0mph but sometimes it will just jump to a crazy amount like 78mph while t...	View
	2003 Dodge Dakota 4.7L check gauge light on truck came in for full service and has CHECK GAUGES light on, all gauges read normal, cust stated that the alt gauge seems to be a little bit higher than before. charging test show 13.3 at idle with a analog gauge you can see the needle fluctuate a bit when th...	View
	2005 Dodge Grand Caravan 3.3L Soft pedal Came in for poor brake pedal and the rear shoes were wore out and the front pads were thin. We replaced the pads and shoes and both rear wheel cylinders because they were seeping. The pedal didn't get very good so we changed the master cylinder. It got ok but ...	View
	1992 Jeep Wrangler 4.0L Excessive Emissions orignally came in failed smog for being way to rich, found the tps reading 4.6 volts all the time running in clear flood, replaced tps know failing nox, at 15 mph hc7, co0, co2 14.7% nox 1400, at 25 mph hc 3, co0, co2 15.0%, nox 200, tested o2 again switching ...	View
	2003 Jeep G. Cherokee 2.7L solenoid Hello This WG 2003 Grand Cherokee is europen diesel version (2.7 CRD). Engine and transmission from Mercedes. TCM will go to limp home mode sometimes with code "Power supply to solenoid". ECM will set code P0700. There is a TSB (21-009-08) regarding a very ...	View

Fixes & Summaries for Chrysler

	Fix/Summary	Answers
	2000 Chrysler Town & Country 3.8L tcm Found that the wiring harness under the battery chafed to the frame and shorted the b+ feed to the fused 12 volt start signal to the tcm . it caused the tcm to shut down and go in to protect mood. thank you all for your help.	8
	2001 Chrysler Town & Country 3.8L master cylinder The customer has not yet return from Florida. Sorry Friends but feel I let my customer down.When he returns I will replace the abs hcu. I beleeve from some of the replies I got thats,going to fix the problem.	33
	2005 Chrysler Sebring 2.4L Front Crank Seal I did find the crankshaft with alot of end play. Thanks to all that replied. This system is great. Chuck's Automotive	15
	1998 Dodge Caravan 3.3L emmision rejection ta all thank you, we put pcm in flashed it go the monitors to run and passed emmissions.	2
	2002 Dodge Durango 4.7L MIL Lamp on I was waiting to post, until I heard what the dealer told the customer, but customer has not gotten back to me - replies agreed that the Chrysler website and the dealer did not have the proper information - perhaps the current flash was the latest and the PCM ... Trouble codes: P0456.	4
	2002 Dodge Grand Caravan 3.8L turn signals, w/s wipers I have not been able to experience the symptom myself yet. There were 3 grounds for the BCM. I disassembled and cleaned the one at the starter, for the two that are in the B pillars I ran an auxilary ground to them. I also disconnected the battery and touched ...	6
	2003 Jeep Grand Cherokee 4.0L MIL Lamp on THANKS TO ALL WHO TOOK THEIR VALUABLE TIM [...] TO HELP ME WITH THIS PROBLEM AFTER I WENT TO ALL THE SUGGESTIONS DROP GAS TANK.SMOKE ALL THE HOSES AND NOTHING HELPED KEITH.GUY AND MICHAEL HIT IT RIGHT IN THE NOSE I USED THE VACUUM PUMP TO TEST THE LDP VENT VALVE AN... Trouble codes: P-0455 (evap lrge leak found).	8
	2005 Jeep Wrangler 4.0L Hesitation, Stall we changed the crank sensor and customer is happy with the results. thanks everyone for your help.	4
	1999 Plymouth Grand Voyager 3.0L pcm Thanks for help,I was afraid of that,luckily this is my own vehicle,I would not have tried this with a customers vehicle.The van has been replaced and is now for sale for parts,thanks again.	8

(Also Available: All, Asian, Chrysler, European, Ford, GM.)

Copyright ©1995-2008 iATN. All rights reserved. Terms of Use | Privacy Policy